Vehicle fuel system Renault Duster 1

Functional diagram of the fuel supply system
Fuel pump assembly, fuel gauge and fuel filter Fuel supply system without fuel return branch to the tank. The fuel supply pressure is independent of the engine load. The system consists of: fuel distribution ramp (1)...

Functional diagram of the fuel supply circuit (with external filter)
Fuel supply system without fuel return branch to the tank. The fuel supply pressure is independent of the engine load. The system consists of: ramps (7) without fuel drain line and fuel pressure regulator, single...

Manual priming pump (K9K engine)
Removing Place the car on a two post lift. Remove: fuel supply line protection nuts (1) fuel supply line protection (2). Disconnect the fuel supply line from the side of the fuel tank at the point (3). Plug the holes...

Fuel filter for diesel fuel
Removing Place the car on a lift. Remove: plastic screen under the fuel filter, right front fender mounting bolts (1). Slightly move aside the shield of the right front wheel arch. Filter type MAHLE Remove: nuts of...

Fuel pressure check (K4M engine)
Place the car on a two post lift. Turn off the ignition Remove: nuts (1) and mounting bolt (2) from the fuel line protection shield, fuel line protection. Disconnect fitting (3) fuel supply line. Attach: tee (Mot....

Fuel consumption check (K4M engine)
Place the car on a two post lift. Switch off the ignition. Remove: nuts (1) and mounting bolt (2) from the fuel line protection shield, fuel line protection. Disconnect fitting (3) fuel supply line. Attach: tee (Mot....

Draining the fuel tank
Disconnect the battery. Models with K4M engine Disconnect the inlet fitting fuel lines from the rail (1). Install tee (Mot. 1311-08) at the point (2). Connect a pneumatic fuel transfer pump to the tee outlet (3). Models...

Fuel tank — removal and installation
Tightening torques Fuel tank bolts 21 Nm Bolts of fastening of the final pipeline to catalytic converter 21 Nm Catalytic Converter to Exhaust Manifold Bolts 21 Nm fastening nut «mass» wires to body 8 Nm Removing Here is...

Fuel level sensor module
Removing Disconnect the battery. Fold out the rear seat cushion. With the aid of a device (Car. 1363) remove the plug from the access hatch cover. Note: Take measures to prevent leakage of fuel in the fuel inlet and...